Chevrolet HHR Recalls

NHTSA has issued 3 safety recalls for the Chevrolet HHR, covering model years 2006 through 2011. The 2010 model year has the most, with 3 separate campaigns against it. The largest single recall covered 2,191,014 vehicles. The most recent was reported to NHTSA on April 10, 2014.

Total recalls: 3
Model years affected: 6
Most recalled part: No repeat
Latest recall: 2014

Chevrolet HHR recalls by model year

How many campaigns were issued against each model year. One recall often covers several years at once, so these add up to more than the 3 total.

20112 recalls20103 recalls20093 recalls20082 recalls20072 recalls20062 recalls

All Chevrolet HHR recalls

Each entry is an official NHTSA campaign, shown with the defect, consequence, and remedy exactly as the manufacturer reported them, newest first.

14V171000Electrical systemReported April 10, 2014

ELECTRICAL SYSTEM:IGNITION

Model years affected: 2006–2011

The problem

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

What can happen

If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

The fix

General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

Vehicles affected: 2,191,014
Maker's recall no.: 14113,14133
Owners notified: April 18, 2014

Read campaign 14V171000 on NHTSA.gov ↗

14V153000SteeringReported March 31, 2014

STEERING:ELECTRIC POWER ASSIST SYSTEM

Model years affected: 2009–2010

The problem

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

What can happen

If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

The fix

GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

Vehicles affected: 1,373,177
Maker's recall no.: N140115
Owners notified: July 17, 2014

Read campaign 14V153000 on NHTSA.gov ↗

14V047000AirbagReported February 10, 2014

AIR BAGS

Model years affected: 2006–2011

The problem

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

What can happen

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

The fix

GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Vehicles affected: 2,190,934
Maker's recall no.: 13454/14063/14092
Owners notified: April 18, 2014

Read campaign 14V047000 on NHTSA.gov ↗

What to do if your Chevrolet HHR is on this list

A recall listed here applies to a range of vehicles, not to every car of that model year. Manufacturers narrow it down by build date and VIN, so the only way to know whether yours is included is to check the VIN. You can do that free on NHTSA's recall lookup, or by calling any franchised dealer for that brand with your VIN in hand.

Recall repairs are free. Under federal law the manufacturer has to fix a safety defect at no charge, and there is no mileage limit and no expiry on that obligation for vehicles under 15 years old. A dealer cannot charge you for the parts, the labour, or the diagnosis on a recall repair, and you do not need to have bought the car there. If a dealer asks you to pay, that is worth escalating to the manufacturer's customer line, which is listed in the remedy text of each recall above.

Recalls do not block a title transfer or registration in any state. You can legally buy, sell, or register a car with an open recall, and sellers are generally not required to fix one first. That said, an open recall is worth raising before money changes hands, especially one with a do-not-drive advisory. If you are buying, run the VIN before you hand over the payment; if you are selling, telling the buyer about an open recall costs you nothing and avoids a dispute later.

Chevrolet HHR recall questions

How many recalls does the Chevrolet HHR have?

NHTSA lists 3 recall campaigns for the Chevrolet HHR across model years 2006 to 2011. That count covers recalls filed from 2010 onward. Not every campaign applies to every car of that model year, because manufacturers limit recalls by build date and VIN.

Which Chevrolet HHR model year has the most recalls?

The 2010 Chevrolet HHR carries the most, with 3 recall campaigns. A high count does not automatically mean a worse car: a single supplier fault can trigger a recall across an entire production run, and manufacturers that report problems quickly tend to show more campaigns.

Are Chevrolet HHR recall repairs free?

Yes. Federal law requires the manufacturer to repair a safety recall at no cost, including parts and labour, on vehicles under 15 years old. There is no mileage limit, and you do not have to be the original owner or have bought the car from that dealer.

Can I sell or register a Chevrolet HHR with an open recall?

Yes. An open recall does not stop a title transfer or registration in any state, and private sellers are generally not required to repair one first. Dealers face stricter rules on some safety recalls. If you are buying, check the VIN before you pay; the repair is free, but you want to know what you are taking on.

Other Chevrolet recalls

Chevrolet Tahoe recalls54 Chevrolet Silverado 1500 recalls53 Chevrolet Suburban recalls42 Chevrolet Silverado 3500 recalls41 Chevrolet Malibu recalls39 Chevrolet Express recalls33

Where this data comes from

Every recall on this page is published by the National Highway Traffic Safety Administration, the federal agency that oversees vehicle safety recalls in the United States. We pull the full recall file from NHTSA and reproduce the campaign number, defect description, consequence, and remedy exactly as the manufacturer reported them. NHTSA data is in the public domain.

Source:: NHTSA Office of Defects Investigation
NHTSA data as of:: July 18, 2026
Coverage:: Recalls from 2010 onward

Check your VIN on NHTSA.gov ↗

Buying or selling this car?

🔧All Chevrolet recalls→🔑Paperwork for buying a used car→📝Paperwork for selling a car→📄Title transfer rules by state→📑Vehicle registration documents explained→🚗Recalls by make and model→

Last reviewed: 2026-07-18 · Reviewed by the Car Paperwork editorial team · Independent resource · Not legal advice

⚠ Independent resource — check your VIN before actingCar Paperwork is not affiliated with NHTSA, any manufacturer, or any dealer. This page lists recalls issued for a model, which is not the same as a recall on your car: only a VIN check confirms that. Recall records are also updated by NHTSA continuously, so treat this as a starting point and confirm anything urgent with NHTSA or a franchised dealer. Nothing here is legal or repair advice.