Chevrolet Monte Carlo Recalls

NHTSA has issued 4 safety recalls for the Chevrolet Monte Carlo, covering model years 1998 through 2007. Engine and cooling faults account for 2 of them, more than any other part of the vehicle. The 2004 model year has the most, with 3 separate campaigns against it. The largest single recall covered 5,877,718 vehicles. The most recent was reported to NHTSA on October 26, 2015.

Total recalls: 4
Model years affected: 10
Most recalled part: Engine and cooling
Latest recall: 2015

Chevrolet Monte Carlo recalls by model year

How many campaigns were issued against each model year. One recall often covers several years at once, so these add up to more than the 4 total.

20071 recall20061 recall20051 recall20043 recalls20032 recalls20022 recalls20012 recalls20002 recalls19991 recall19981 recall

All Chevrolet Monte Carlo recalls

Each entry is an official NHTSA campaign, shown with the defect, consequence, and remedy exactly as the manufacturer reported them, newest first.

15V701000Engine and coolingReported October 26, 2015

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Model years affected: 1998–2004

The problem

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

What can happen

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

The fix

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Vehicles affected: 1,003,556
Maker's recall no.: 15757
Owners notified: February 19, 2016

Read campaign 15V701000 on NHTSA.gov ↗

15V201000Engine and coolingReported April 6, 2015

ENGINE AND ENGINE COOLING:ENGINE

Model years affected: 2004

The problem

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

What can happen

The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

The fix

GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

Vehicles affected: 330,742
Maker's recall no.: 14574
Owners notified: April 24, 2015

Read campaign 15V201000 on NHTSA.gov ↗

14V400000Electrical systemReported July 3, 2014

ELECTRICAL SYSTEM:IGNITION

Model years affected: 2000–2005

The problem

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

What can happen

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

The fix

Vehicles affected: 5,877,718
Maker's recall no.: 14350
Owners notified: September 8, 2014

Read campaign 14V400000 on NHTSA.gov ↗

14V355000Electrical systemReported June 23, 2014

ELECTRICAL SYSTEM:IGNITION

Model years affected: 2006–2007

The problem

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

What can happen

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.

The fix

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.

Vehicles affected: 3,141,731
Maker's recall no.: 14299
Owners notified: September 23, 2014

Read campaign 14V355000 on NHTSA.gov ↗

What to do if your Chevrolet Monte Carlo is on this list

A recall listed here applies to a range of vehicles, not to every car of that model year. Manufacturers narrow it down by build date and VIN, so the only way to know whether yours is included is to check the VIN. You can do that free on NHTSA's recall lookup, or by calling any franchised dealer for that brand with your VIN in hand.

Recall repairs are free. Under federal law the manufacturer has to fix a safety defect at no charge, and there is no mileage limit and no expiry on that obligation for vehicles under 15 years old. A dealer cannot charge you for the parts, the labour, or the diagnosis on a recall repair, and you do not need to have bought the car there. If a dealer asks you to pay, that is worth escalating to the manufacturer's customer line, which is listed in the remedy text of each recall above.

Recalls do not block a title transfer or registration in any state. You can legally buy, sell, or register a car with an open recall, and sellers are generally not required to fix one first. That said, an open recall is worth raising before money changes hands, especially one with a do-not-drive advisory. If you are buying, run the VIN before you hand over the payment; if you are selling, telling the buyer about an open recall costs you nothing and avoids a dispute later.

Chevrolet Monte Carlo recall questions

How many recalls does the Chevrolet Monte Carlo have?

NHTSA lists 4 recall campaigns for the Chevrolet Monte Carlo across model years 1998 to 2007. That count covers recalls filed from 2010 onward. Not every campaign applies to every car of that model year, because manufacturers limit recalls by build date and VIN.

Which Chevrolet Monte Carlo model year has the most recalls?

The 2004 Chevrolet Monte Carlo carries the most, with 3 recall campaigns. A high count does not automatically mean a worse car: a single supplier fault can trigger a recall across an entire production run, and manufacturers that report problems quickly tend to show more campaigns.

Are Chevrolet Monte Carlo recall repairs free?

Yes. Federal law requires the manufacturer to repair a safety recall at no cost, including parts and labour, on vehicles under 15 years old. There is no mileage limit, and you do not have to be the original owner or have bought the car from that dealer.

Can I sell or register a Chevrolet Monte Carlo with an open recall?

Yes. An open recall does not stop a title transfer or registration in any state, and private sellers are generally not required to repair one first. Dealers face stricter rules on some safety recalls. If you are buying, check the VIN before you pay; the repair is free, but you want to know what you are taking on.

Other Chevrolet recalls

Chevrolet Tahoe recalls54 Chevrolet Silverado 1500 recalls53 Chevrolet Suburban recalls42 Chevrolet Silverado 3500 recalls41 Chevrolet Malibu recalls39 Chevrolet Express recalls33

Where this data comes from

Every recall on this page is published by the National Highway Traffic Safety Administration, the federal agency that oversees vehicle safety recalls in the United States. We pull the full recall file from NHTSA and reproduce the campaign number, defect description, consequence, and remedy exactly as the manufacturer reported them. NHTSA data is in the public domain.

Source:: NHTSA Office of Defects Investigation
NHTSA data as of:: July 18, 2026
Coverage:: Recalls from 2010 onward

Check your VIN on NHTSA.gov ↗

Buying or selling this car?

🔧All Chevrolet recalls→🔑Paperwork for buying a used car→📝Paperwork for selling a car→📄Title transfer rules by state→📑Vehicle registration documents explained→🚗Recalls by make and model→

Last reviewed: 2026-07-18 · Reviewed by the Car Paperwork editorial team · Independent resource · Not legal advice

⚠ Independent resource — check your VIN before actingCar Paperwork is not affiliated with NHTSA, any manufacturer, or any dealer. This page lists recalls issued for a model, which is not the same as a recall on your car: only a VIN check confirms that. Recall records are also updated by NHTSA continuously, so treat this as a starting point and confirm anything urgent with NHTSA or a franchised dealer. Nothing here is legal or repair advice.